advertisement

Technology could have caused Prius problems

Thursday, February 4, 2010 | 8:11 p.m. CST; updated 8:58 a.m. CST, Friday, February 5, 2010
Toyota issued a second recall to deal with its sticky pedal problem. This recall differs from the company’s Floor Mat Entrapment recall, which dealt with pedals getting stuck under floor mats in the car. The pedal recall addresses the friction between grooves and wear or possible damage to grooves at the end of gas pedals, which affects the way the grooves move against each other. Too much wear can cause the pedal to be slow to return when the driver lets off the gas pedal. In rare cases, the grooves can become permanently stuck.

NEW YORK — Your most expensive piece of electronics probably is not your flat panel TV or your computer. More likely, it’s your car, which can pack 50 microprocessors to control everything from the fuel mix to the rearview mirrors.

The recalls and other technical problems besetting Toyota in the last few weeks highlight the risks of relying on electronics instead of the mechanical rods and cables that controlled vehicles for most of the 20th century.

Such advancements bring many benefits, but the worry is that the car is a computer on wheels that could freeze up and potentially crash. No less a computer celebrity than Apple Inc. co-founder Steve Wozniak has said his Toyota Prius sometimes accelerates on its own.

For many years, a car’s gas and brake pedals were connected directly to the throttle and the brake assembly. Now computers and electronic sensors govern many of those functions, as well as a vehicle’s exhaust system, its inside temperature and a host of other operations.

Those design changes were reviewed this week when the National Highway Traffic Safety Administration began looking into 124 reports from consumers that their Toyota Priuses momentarily lost braking ability while traveling over uneven roads, potholes or bumps.

The Prius problem is part of a broader issue for Toyota: Accelerators in its non-hybrid cars can get trapped under floor mats or become stuck on their own and fail to return to the idle position. Toyota has recalled eight top-selling models, involving 2.3 million cars in the U.S. alone.

In the Prius, in addition to traditional hydraulic brakes, the car has an electronically operated braking system to recover some of the energy lost as the car slows. Some of that energy is sent to the battery that powers the Prius’ electric motor. The hybrid design saves fuel and reduces emissions, it increases the complexity of the car. One explanation Toyota has offered for the Prius problems is that there’s a time lag when the Prius switches between its gas engine and the electric motor. The car would then be delayed in switching between the traditional hydraulic brakes and the electronic braking system.

On Thursday, Toyota instead pointed toward the antilock braking system. Antilock brakes engage and disengage many times per second to prevent skidding. The company said it changed settings on the assembly line to prevent “inconsistent brake feel during slow and steady application of brakes on rough or slick road surfaces.”

In 2005, Toyota announced a recall of 160,000 Priuses following reports that brake lights lit up for no reason and gasoline engines shut down of their own accord. The culprit was the software controlling critical car functions.

Software also appears to be to blame at Ford Motor Co., which said Thursday it plans to fix 17,600 Mercury Milan and Ford Fusion gas-electric hybrids because of a glitch that can give drivers the impression the brakes have failed.

The automaker says the problem occurs in transition between two braking systems and at no time are drivers without brakes. Jake Fisher, senior automotive engineer for Consumer Reports magazine, criticized another electronic feature of some Toyotas and Lexuses: the push-button ignition.

To turn the engine off in an emergency, such as when the accelerator is stuck, Toyota and Lexus drivers must hold the button for three seconds. Drivers of other makes such as Cadillac, Nissan and Infiniti can shut off the engines by pushing the start button more than once. A driver in an emergency may not think to hold the button, but likely would push it several times, Fisher said.

Dennis Virag, president of the Automotive Consulting Group, said Toyota has erred in not adopting a brake override system for all its cars — one that shuts off the fuel supply to the engine if the brakes are engaged and the accelerator is down.

Most other manufacturers have such systems, which can save lives even when the gas pedal is working as intended.

Associated Press reporters Stephen Manning and Tom Krisher contributed to this report.

 


Like what you see here? Become a member.


Show Me the Errors (What's this?)

Report corrections or additions here. Leave comments below here.

You must be logged in to participate in the Show Me the Errors contest.


Comments

Leave a comment

Speak up and join the conversation! Make sure to follow the guidelines outlined below and register with our site. You must be logged in to comment. (Our full comment policy is here.)

  • Don't use obscene, profane or vulgar language.
  • Don't use language that makes personal attacks on fellow commenters or discriminates based on race, religion, gender or ethnicity.
  • Use your real first and last name when registering on the website. It will be published with every comment. (Read why we ask for that here.)
  • Don’t solicit or promote businesses.

We are not able to monitor every comment that comes through. If you see something objectionable, please click the "Report comment" link.

You must be logged in to comment.

Forget your password?

Don't have an account? Register here.

advertisements